Development and Performance Evaluation of Silicone-Based Hydrophobic Coatings for Anti-Soiling Applications on Solar PV Glass
DOI:
https://doi.org/10.26740/vubeta.v3i2.48779Keywords:
Hydrophobic coatings Solar PV panels Water Contact Angle Dust accumulation TransparencyAbstract
Soiling is a major cause of performance degradation in solar photovoltaic (PV) systems, particularly in tropical environments characterized by high humidity and persistent dust accumulation. This study presents the development and experimental evaluation of silicone-based hydrophobic coatings designed to enhance the anti-soiling and water-repellent properties of PV glass substrates. Three coating formulations with varying silicon dioxide (SiO2) nanoparticle contents, 2.03 wt% (HC1), 3.34 wt% (HC2), and 0 wt% (HC3), were prepared and systematically characterized. Coating performance was assessed using water droplet mobility tests, static water contact angle (WCA) measurements, and controlled dust-accumulation experiments. Among the formulations, HC2 exhibited the best overall performance, achieving the highest average WCA (94.3°), fastest droplet runoff time (0.8 s), and lowest dust accumulation (4.4 mg). The results confirm that increasing SiO2 nanoparticle concentration enhances surface hydrophobicity and reduces dust adhesion by modifying surface roughness. These findings highlight the potential of optimized silicone-SiO2 coatings as a cost-effective, passive anti-soiling solution for improving the operational efficiency of solar PV systems, particularly in dust-prone environments.
References
[1] Q. Hassan et al., "The renewable energy role in the global energy Transformations," Renewable Energy Focus, vol. 48, p. 100545, 2024. https://doi.org/10.1016/j.ref.2024.100545.
[2] K. Aliyu Musa, M. Z. Ahmed, A. Abdulkadir Hamidu, U. Jafaru, and H. Aisha Hassan Abdalla, "Real-Time Energy Demand Forecasting and Adaptive Demand Response Optimization for IoT-Enabled Smart Grids," Vokasi Unesa Bulletin of Engineering, Technology and Applied Science, vol. 2, no. 2, pp. 366-375, 06/20 2025. https://doi.org/10.26740/vubeta.v2i2.36818.
[3] A. Ghoneim, K. M. Kandil, A. M. Mohammedein, and I. M. Kadad, "Environmental assessment of solar heating and cooling systems in Kuwait climate," Green Energy and Technology, Article vol. 31, pp. 439-454, 2010. https://doi.org/10.1007/978-1-4419-1017-2_28.
[4] P. Rani, R. Taya, and V. P. Reddy, "A Review on Solar Energy and Different Electricity Generations," International Conference on Power Energy, Environment & Intelligent Control (PEEIC), pp. 231-234. 2023. https://doi.org/10.1109/PEEIC59336.2023.10451552.
[5] N. Aste, C. Del Pero, F. Leonforte, S. Ounis, and A. M. G. Abdelrahim, "The role of photovoltaic technology in achieving net zero energy target in residential buildings," Energy Strategy Reviews, vol. 55, p. 101543, 2024. https://doi.org/10.1016/j.esr.2024.101543.
[6] D. S. Renné, "Progress, opportunities and challenges of achieving net-zero emissions and 100% renewables," Solar Compass, vol. 1, p. 100007, 2022. https://doi.org/10.1016/j.solcom.2022.100007.
[7] P. Borah, L. Micheli, and N. Sarmah, "Analysis of Soiling Loss in Photovoltaic Modules: A Review of the Impact of Atmospheric Parameters, Soil Properties, and Mitigation Approaches," Sustainability, vol. 15, no. 24, p. 16669. https://doi.org/10.3390/su152416669.
[8] W. Javed, B. Guo, B. Figgis, and B. Aïssa, "Dust potency in the context of solar photovoltaic (PV) soiling loss," Solar Energy, vol. 220, pp. 1040-1052, 2021. https://doi.org/10.1016/j.solener.2021.04.015.
[9] M. Khalilabad et al., “Superhydrophobic coatings for photovoltaic modules: A review on performance enhancement and cleaning frequency reduction,” Energy Reports, vol. 8, no. 1, pp. 123–135, 2022. https://doi.org/10.1016/j.egyr.2021.12.002.
[10] M. Saleh, A. Dwivedi, and S. Makki, “An enhancement of the solar panel efficiency: A comprehensive review,” Frontiers in Energy Research, vol. 10, p. 937155, 2022. https://doi.org/10.3389/fenrg.2022.937155.
[11] S. A. Sulaiman, M. R. M. Razif, and N. M. Norazman, “Field analysis of soiling effect on grid-connected photovoltaic (PV) systems in Malaysia,” Int. J. Electr. Comput. Eng., vol. 10, no. 2, p. 1083, 2020. https://doi.org/10.11591/ijece.v10i2.
[12] Y. N. K. Rajbahadur, A. Kumar, S. Negi, and S. Kar, "Evaluation of hydrophobic/hydrophilic and antireflective coatings for photovoltaic panels," Journal of Coatings Technology and Research, 2024. https://doi.org/10.1007/s11998-024-00929-0.
[13] M. A. M. L. D. Jesus, G. Timò, C. Agustín-Sáenz, I. Braceras, M. Cornelli, and A. D. M. Ferreira, "Anti-soiling coatings for solar cell cover glass: Climate and surface properties influence," Solar Energy Materials and Solar Cells, Article vol. 185, pp. 517-523, 2018. https://doi.org/10.1016/j.solmat.2018.05.036.
[14] PV Magazine, “Hydrophobic nanocoating to reduce soiling in solar panels,” Dec. 14, 2022.
[15] A. Nistor, "Silicones involved in surface modification of materials based on organic polymers," in Recent Developments in Silicone-Based Materials, 2010, pp. 179-221.
[16] L. Zhang et al., "Transparent hydrophilic-oleophobic waterborne coating for multifunctional applications," Progress in Organic Coatings, vol. 191, p. 108454, 2024/06/01/ 2024. https://doi.org/10.1016/j.porgcoat.2024.108454.
[17] I. Torun et al., "Water Impact Resistant and Antireflective Superhydrophobic Surfaces Fabricated by Spray Coating of Nanoparticles: Interface Engineering via End-Grafted Polymers," Macromolecules, Article vol. 51, no. 23, pp. 10011-10020, 2018. https://doi.org/10.1021/acs.macromol.8b01808.
[18] S. Ke et al., "Recent developments in the fabrication, performance, and application of transparent superhydrophobic coatings," Advances in Colloid and Interface Science, Review vol. 342, 2025. https://doi.org/10.1016/j.cis.2025.103537.
[19] X. Yao et al., "Preparation of wood super-hydrophobic coating using the sand-in method," Progress in Organic Coatings, Article vol. 192, 2024. https://doi.org/10.1016/j.porgcoat.2024.108498.
[20] R. Li, Z. Chen, Y. Lu, H. Wu, Q. Jiang, and G. Jiang, "Water droplet impact on perfluoropolyether-based liquid-like surfaces," Colloids and Surfaces A: Physicochemical and Engineering Aspects, Article vol. 674, 2023. https://doi.org/10.1016/j.colsurfa.2023.131837.
[21] K. Ilse, M. Z. Khan, N. Voicu, V. Naumann, C. Hagendorf, and J. Bagdahn, "Advanced performance testing of anti-soiling coatings - Part II: Particle-size dependent analysis for physical understanding of dust removal processes and determination of adhesion forces," Solar Energy Materials and Solar Cells, Article vol. 202, 2019. https://doi.org/10.1016/j.solmat.2019.110049.
[22] M. Danish, "Contact Angle Studies of Hydrophobic and Hydrophilic Surfaces," Handbook of Magnetic Hybrid Nanoalloys and their Nanocomposites, 2022, pp. 761-782.
[23] E. W. Roger et al., "Ultra-high transmittance through nanostructure-coated glass for solar cell applications," Proc.SPIE, 2011, vol. 8035, p. 80350X. https://doi.org/10.1117/12.888129.
Downloads
Published
How to Cite
Issue
Section
License
Copyright (c) 2026 Ahmad A. Thaiubudeen, Shaharin A. Sulaiman, Syed Awais Ali Awais
This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.
Abstract views: 7
,
PDF Downloads: 5
